Product ID:RAPID ACTIVATOR 3,103,PART B
MSDS Date:01/31/1995
FSC:3426
NIIN:00-212-8055
Kit Part:Y
MSDS Number: BXQCY

RAPID ELECTROPLATING PROCESS INC

1603 S MICHIGAN AVE
CHICAGO, IL 60616
US

Emergency Phone: 312-684-8348/800-424-9300(CHEMTREC)

Info Phone: 312-922-0952

Preparer: R.F. RAPIDS

Cage: 98108

RAPID ELECTROPLATING PROCESS INC

CHICAGO, IL 60605-2815 US

Cage: 98108

PHOSPHORIC ACID (SARA 313) (CERCLA)

CAS: 7664-38-2

RTECS: TB6300000

Fraction By Weight: <10%

OSHA PEL 1 MG/M3

ACGIH TLV: 1 MG/M3/3 STEL; 9495

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

THIOUREA (SARA 313) (CERCLA)

CAS: 62-56-6

RTECS: YU2800000

Fraction By Weight: <5%

EPA Report Quantity: 10 LBS

DOT Report Quantity: 10 LBS

NON-HAZARDOUS INGREDIENTS

Fraction By Weight: >85%

Routes of Entry: Inhalation:NO Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:EYES, SKIN, RESPIRATORY
& GI TRACTS. ACUTE- CORROSIVE. MAY CAUSE EYE BURNS & INJURY. MAY
CAUSE SKIN IRRITATION & BURNS. MAY CAUSE ALLERGIC REACTION.
INHALING MIST MAY IRRITATE THROAT, NO SE. INGESTION CAN BURN MOUTH
& STOMACH.CHRONIC- SLIGHTLY TOXIC.
Explanation of Carcinogenicity:CONTAINS THIOUREA.
Effects of Overexposure:SEVERE IRRITAITON, BURNS, EYE INJURY, PAIN,
ALLERGIC REACTION
Medical Cond Aggravated by Exposure:PRE-EXISTING LUNG DISEASE, SKIN
DISORDER

First Aid:CALL PHYSICAN IMMEDIATELY. EYE/SKIN:IMMEDIATELY FLUSH WITH
WATER FOR 15 MINUTES. HOLD EYELIDS OPEN. INHALED:REMOVE TO FRESH
AIR. PROVIDE CPR/OXYGEN IF NEEDED. TREAT FOR SHOCK. ORAL:IF
CONSCIOUS, RINSE MOUTH & DRINK WATER. SLOWLY TAKE ALUMINUM
HYDROXIDE GEL/MILK OF MAGNESIA. DO NOT TAKE CARBONATES/SODA. DO NOT
INDUCE VOMITING. IF VOMITING OCCURS, KEEP HEAD BELOW HIPS.

Flash Point:NONE
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE, FOAM OR DRY CHEMICAL
FOR SURROUNDING FIRE. USE WATER SPRAY TO COOL FIRE EXPOSED
CONTAINERS.
Fire Fighting Procedures:WEAR FULL PROTECTIVE CLOTHING AND
NIOSH-APPROVED SELF-CONTAINED BREATHING APPARATUS.
Unusual Fire/Explosion Hazard:MAY FORM HAZARDOUS AND/OR CORROSIVE
DECOMPOSITION PRODUCTS.

Spill Release Procedures:WEAR ACID-RESISTANT CLOTHING, BOOTS, GLOVES
AND FACE SHIELD. VENTILATE AREA. STOP FLOW OF MATERIAL.
CONTAIN/ABSORB SPILLS WITH DRY SAND, EARTH, VERMICULITE. TRANSFER
TO CONTAINER FOR DISPOSAL. AFTER P ICKUP, CLEAN AREA WITH MILD
ALKALINE AND WATER.
Neutralizing Agent:BAKING SODA (SODIUM BICARBONATE), SODA ASH (SODIUM
CARBONATE), LIME;CA HYDROXIDE

Handling and Storage Precautions:STORE AWAY FROM INCOMATIBLE MATERIALS.
DO NOT MIX WITH OTHER CHEMICALS. KEEP OUT OF REACH OF CHILDREN. USE
IN WELL VENTILATED AREA.
Other Precautions:WARNING! CORROSIVE. FOR INDUSTRIAL USE ONLY. READ AND
FOLLOW ALL LABEL DIRECTIONS AND PRECAUTIONS. WASH THOROUGHLY AFTER
HANDLING. AVOID CONTACT WITH EYES AND SKIN. DO NOT BREATH VAPORS.
KEEP PRODUCT ABOVE 32F. CORROSIVE TO METALS.

Respiratory Protection:IF WORKING IN CONFINED AREAS, IF EXCESSIVE
MISTING IS EXPECTED OR IF EXPOSURE MAY OR DOES EXCEED RECOMMENDED
PERMISSIBLE EXPOSURE LIMITS (PEL), WEAR NIOSH-APPROVED RESPIRATORY
PROTECTION; FOR DUST/MIS T (REFER TO 29 CFR 1910.134).
Ventilation:USE GENERAL OR LOCAL EXHAUST VENTILATION TO MEET TLV
REQUIREMENTS.
Protective Gloves:RUBBER, NEOPRENE, PLASTIC
Eye Protection:CHEMICAL SPLASH GOGGLES & FACE SHIELD
Other Protective Equipment:SAFETY SHOWER AND EYE WASH FOUNTAIN SHOULD
BE LOCATED NEARBY. WEAR APPROPRIATE PROTECTIVE CLOTHING FOR RISK OF
EXPOSURE.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES.
Supplemental Safety and Health
KEY1:C1. THIS PRODUCT IS A KIT CONSISTING OF TWO PARTS. PART A, HAS PNI
A; PART B HAS PNI B, SAME NSN.

HCC:C1
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:B.P. Text:>212F,>100C
Melt/Freeze Pt:M.P/F.P Text:<32F,<0C
Vapor Pres:23.8 @ 77F
Vapor Density:0.8
Spec Gravity:1.05
pH:1.5
Evaporation Rate & Reference:<1 (N-BUTYL ACETATE=1)
Solubility in Water:MISCIBLE
Appearance and Odor:BLUE-GREEN LIQUID; SLIGHT MUSTY ODOR

Stability Indicator/Materials to Avoid:YES
CHLORINE, CHLORATE, NITRATE, NITRITE, SULFIDES, CYANIDES, ALKALIES,
HIGHLY REACTIVE METALS
Stability Condition to Avoid:EXCESSIVE HEATING TO DRYNESS
Hazardous Decomposition Products:PHOSPHORUS OXIDES, SULFUR OXIDES, AND
AMMONIA

Waste Disposal Methods:THE UNNEUTRALIZED PRODUCT, WHEN DISPOSED, IS A
HAZARDOUS WASTE. DISPOSE OF IN ACCORDANCE WITH ALL LOCAL, STATE AND
FEDERAL REGULATIONS. LANDFILL NEUTRALIZED PRODUCT IF PERMITTED.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.